无锡科达移动脚手架厂家【官网】生产:【移动脚手架】【门式脚手架】【梯形脚手架

无锡科达【移动脚手架】生产厂家

示例图片三
网站首页 > 新闻资讯 > 移动脚手架

厂家揭示移动脚手架使用注意事项【总结篇】

移动脚手架使用期间,不得任意拆除杆件。当模板支架基础下或相邻处有设备基础、管沟时,在支架使用过程中不得开挖,否则必须采取。新型脚手架按国标生产降为0.9公斤,以一个年生产扣件1000万套的公司为例,可节省原材料2000多吨,节约生产成本约700余万元,同时,还节省了大量能源.

During the use of mobile scaffolds, no rod must be removed at will. When there are equipment foundation and pipe trench under the foundation of formwork support or adjacent place, it must not be excavated during the use of the support, otherwise it must be adopted. The production of the new scaffolding is reduced to 0.9 kg according to the national standard. Taking a company producing 10 million sets of fasteners annually as an example, it can save more than 2,000 tons of raw materials, save production cost about 7 million yuan, and save a lot of energy.

1、立杆接长除顶步可采用搭接脚手架外,其余各步接头必须采用对接扣件连接。对接、搭接应符合下列规定:搭接长度不应小于1m,应采用不少于2个脚手架固定,端部移动脚手架盖板的边缘至杆端距离不应小于100mm,立杆伤的脚手架应交错布置,两根相邻立杆的接头不应设置在同步内;

1. In addition to lap scaffolding for the top step, butt fasteners must be used for the rest of the joint. Docking and lapping shall conform to the following stipulations: lapping length shall not be less than 1 m, shall be fixed with no less than 2 scaffolding, the distance between the edge of the moving scaffold cover plate at the end and the end of the rod shall not be less than 100 m m, the scaffolding with the damaged upright rod shall be staggered, and the joints of the two adjacent upright rods shall not be set in synchronization;

2、搭设脚手架用的钢管、扣件,使用前必须进行抽样检测,抽检数量按有关规定执行。未经检测或检测不合格的一律不得使用。

2. Pipes and fasteners for scaffolding must be sampled before use, and the quantity of sampled inspection shall be carried out according to relevant regulations. No tests or tests fail to be used.

这种新型脚手架的生产不仅符合国家标准,而且其各项指标大大超越了传统扣件.并在今年召开的全国建筑行业会上予以发布.同时,新型扣件被中国建筑金属结构协会脚手架委员会评为质量信得过产品

The production of this new scaffold not only conforms to the national standard, but also greatly exceeds the traditional fasteners. The new fasteners were issued at the national construction industry meeting this year. Meanwhile, the new fasteners were evaluated as reliable products by the scaffolding Committee of China Construction Metal Structure Association.

3、拆除作业必须由上而下逐步进行,严禁上下同时作业。分段拆除的高差不应大于二步。设有附墙连接件的模板支架,连接件必须随脚手架逐层拆除,严禁先将连接件全部或数步拆除后再拆除支架。 移动脚手架在生产和使用中发挥重要的作用和价值,展现重要的行业价值和贡献。脚手架在搭设中按照一定的方式和原理进行,按照正常的方式进行连接。

3, the demolition work must be carried out from top to bottom, and it is strictly prohibited to operate at the same time. The height difference should be greater than two steps. The formwork bracket with wall-attached connectors must be removed layer by layer with the scaffolding. It is strictly prohibited to remove all or several steps of the connectors before removing the bracket. Mobile scaffolding plays an important role and value in production and use, showing important industry value and contribution. Scaffolding is set up in accordance with certain ways and principles, in accordance with the normal way to connect.

4、卸料时应符合下列规定:严禁将钢管、扣件由高处抛掷至地面。

4, discharge should meet the following requirements: strictly prohibit throwing the steel pipe and fastener from high to the ground.



标签:   脚手架 移动脚手架 脚手架厂家 梯形脚手架 门式脚手架